Page 7 - GK12192016F1_Documentation_DodgeMotorHomeRecords_06241969

Service Department
New Truck Pre-Delivery
... ___... .J-*?. ............ .J
Service Inspection

Noto: Inspection and/or correction of the operations
listed on this form are considered part of the dealer's
new truck preparation and handling costs.

3^ 3- /.7/Z
S.O. No. Model Serial No.

Dealer Code No. Region

City, State, Zip Date

Inspect the following items and correct as necessary:
On Hoist
Consult Shop Manual and Service Bulletins for
adjustment standards and torque specifications.
T 1. Lubricate truck. Check fluid level LL 22. Battery and starter cable condition -------- 42. Window regulators, door handles,
of: Transmission, Transfer Case, and routing locks and glove box
Differentia! and Aux. Transmission J^^23. Drive belt tension and alignment Outside Vehicle
Installation of spare wheel and 24. Electrical wiring, routing -------- 43. Hood, doors, windows and fenders
tire and adjustment of tire carrier, for fit and paint condition
if so equipped Hydraulic and fuel lines,
connections and routing ---------44. Bumper and mouldings
Wheel bearings
Crankcase vent valve operation --------- 45. Headlamp aim
Wheel nuts and tire pressure
Under Hood Engine Operating Road Test
Steering coupling lock bolt nut,
LT 27. Automatic transmission fluid 46. Instrumeqts, controls and
if so equipped
level, if so equipped accessories
Steering coupling lock pin,
installation, if so equipped 28. Ignition timing and distributor 47. Operation of horn
dwell
Steering gear to frame bolts ---------48. Service and parking brake
29. Throttle linkage and governor,
-----8. Steering linkage, alignment, adjustment 49. Clutch and transmission
torque and cotter pins .------------- 50. Engine performance
King pins (lock in place) ------— 51. Two and three-speed rear axle,
___LT 30. Carburetor idle speed adjustment,
___Jlxx'lO. Brake and fuel lines, connections curb idle if so equipped
and routing 52. Steering performance
----- L_ 31. Carburetor fast idle speed
____11. Exhaust system, connections adjustment ---------53. Squeaks, rattles, or vibrations
and routing
32. Governor, if so equipped ---------54. .Recheck engine oil level after
LL’ 12. Spring clip (U-bolt) nuts road test
^^33. Radiator hoses
1 3. Drive line U-joints Diesel Engine Equipped Truck
34. Manifold heat control valve
Inside Cab
14. Body hold down bolts 55. Bleed air from luberfiner
------ L 35. Brake and clutch pedal free play
Under Hood Engine Off 56. Recheck air cleaner intake
------C. 36. Brake pedal to master cylinder
15. Engine oil level connections
push rod bolt
57. Recheck and adjust engine idle

Steering gear fluid level 37. Clutch pedal to master cylinder
Brake master cylinder fluid level push rod bolt, if so equipped speed
Genera! Operations
18. Clutch master cylinder fluid level --------- 38. Operation of all lights
--------- 58. Assure truck is in clean presentable
19. Windshield washer reservoir --------- 39. Dimmer switch operation condition (remove all tags,
fluid level
--------- 40. Safety belts, operation and stamps and labels), all required
------ L'"' 20. Radiator fluid level and proper anchorage literature is in the glove box, and
anti-freeze protection all deficiencies have been reported
i Front seat operation
■-------- 21. Battery fluid level and charge 59. Assure that owner is properly
condition instructed in the operation of
the truck and all accessories
Remarks: Keep this form in Vehicle History file
Please explain in detail any abnormal conditions. (If necessary use other side) Inspected by

•TLy CHRYSLER
DODGE DIVISION
84-383-9890 Rev. 2-69 MOTORS CORPORATION